The Effect of Isabgol (Plantago psyllium) Mucilage and Shiraz Thyme Essential Oils on Microbial Load and Improving Shelf Life of Fresh-Cut Carrot

Document Type : Research Article

Authors

• Majid Azizi ¹
• Zeinab Safaei ¹
• Somaye Mirmostafaee ²
• Shadi Bolorian ³
• Negar Rahimi ¹

¹ Ferdowsi University of Mashhad

² ferdowsi University of Mashhad

³ Faculty of Food Additive Research Department

https://doi.org/10.22067/jhorts4.v0i0.28162

Abstract

Introduction: Fresh-cut produce graduated to retail during the1990s, especially for lettuce, cabbage, carrots and other similar vegetables. The high microbial loads of these products after harvest can be substantially reduced through a cleaning in flowing chlorinated water and adistribution under ensured controlledrefrigeration. Therefore, a good number of convenient ready-to-use greens were launched to the market in the past decade. Nowadays, theuse of this technology to achieve similar results in fruit products is one of the most challengingtargets for processors. However, there is anumber of issues that still need to beovercomebeforefresh-cut fruit commodities can be sparked off to anoutstanding position in the segment of lightly-treatedrefrigerated foods. The importance of freshly cut products increases day by day. Tissue and cell rupture leads to a decrease in the shelf life of these products. On the other hand, these products due to increased enzyme activity, respiration rate and microbiological considerations that affect the health of these productsrequires highly attention.To increase the shelf life of the products and prevent undesirable changes in cut slices of fruit or vegetables a coating on the surface of these products has been suggested. Mucilages and essential oils of herbs are natural compounds that can be used to create such covers. The advantages of these coatings are their bactericidal effect, maintenanceof pleasant taste and other physical and chemical characteristics of the product and even decrease of environmental pollution. In this research, the effect of natural compounds such as Zataria multiflora essential oil (EO) and Plantagopsyllium mucilage on storage life and microbial load of fresh cut carrot was studied.
Materials and Methods: The research was conducted in two separate experiments on fresh-cut carrot: In the first experiment, the effect of different concentrations of Plantago psyllium mucilage (0,100, 200, and 400mgL-1) and four concentrations of Zataria multiflora essential oil (0,100, 250,and 500 mgL-1), in a factorial experiment on the basis of completely randomized designwith16treatments and three replications was evaluated. In the second experiment application of essential oil and mucilage on microbial load of fresh-cut carrot was examined in a split plot experiment on the basis of randomized complete blocks design with six treatments and three replications which Zataria multiflora EO (500 mgL-1) and Plantago psyllium mucilage (400 mgL-1) was set as main plot and storage time was set as subplot. The serial dilution technique and cultivation in special culture media were used to determine the microbial load. Treated samples were then packaged in polyethylene trays (175mL) and were stored at 4°C. After10 days of treatment different parameters such as weight loss, total soluble solids (TSS), titratable acidity (TA), pH, color, organoleptic properties, the amount of skin whitening and microbial load were evaluated.Means were compared using LSD test at the significant 5% probability level.
Results and Discussion: The results showed that the treatments had a significant effect on weight loss. Essential oil and mucilage treated samples with different concentrations and also a combination of the two had less weight loss than the control. Different concentrations of essential oil and mucilage individually significantly affected titra table acidity, soluble solids and pH. Samples treated with 100 and 250 mgL-1essential oil, and with 100 and 200 mgL-1 mucilage had the highest acidity, and showed significant increase compared to the control. A little color changes occurred in the treated samples and their colors were very close to the control. Combination treatment with 100 mg.L-1essentialoil plus 100 mgL-1mucilagesignificantlyreduced skin whitening of fresh cut carrot. Analysis of variance indicates significant effect of treatments on all microbial contaminations which were evaluated. The means of aerobic mesophilic bacterial contamination and the coliform bacterial contamination were 6.67 log CFU/g and6.37 log CFU/g, respectively. Only mold and yeast contamination significantly increased during storage and was more pronounced in samples treated with psylliummucilage. After 10 days of storage, although some bacterial contamination increased, this increase was not significant. Fungal contamination starts at 5.35 log CFU/g and endsat 6.64 log CFU/g, which is approximately 1.3 log CFU/g increased. E. coli contamination was not observed in samples.According to the standards threshold, in this experiment, aerobic mesophilic bacteria contamination of the samples (except for samples coated with mucilage after 10 days of storage which their contamination exceeded) was in the standard threshold.However, coliform bacteria, mold and yeast contamination in all samples exceeded.
Conclusion: In general, results of this study showed that application of natural compounds of medicinal plants as edible coatings improved the quality and -extend the shelf life of fresh cut carrot. .However, disinfection of the product in this experiment was not sufficient to reduce the microbial contamination properly and treatments used could not reduce it at the standard limits, appropriate disinfection methods such as radiation and higher concentrations are also investigated in order to export this recommended product

Keywords

• Color
• Edible coatings
• Microbial load
• Quality

20.1001.1.20084730.1394.29.3.10.2

References

Adriano D.N., Simes A., Tudela A., Allende R.P., and Maria I.G. 2009. Edible coatings containing chitosan and moderate modified atmospheres maintain quality and enhance phytochemicals of carrot sticks. Journal of Post harvest Biology and Technology, 51: 364–370.

2- Amal S.H., Atress M.M., El-Mogy H.E., Aboul A., and Alsanius B.W. 2010. Improving Strawberry Fruit Storability by Edible Coating as a Carrier of Thymol or Calcium Chloride. Journal of Horticultural Science & Ornamental Plants, 2 (3): 88-97.

3- Azizi M., Farzad S., Jafarpour M.F., and Jahanbakbsh V. 2006. Inhibitory effect of some medicinal plants essential oils on post-harvest fungal disease of citrus fruits KMLT. Journal of Science and Technology.6: 2.685-691.

4- Bahramian F, Javanmard M. 2009. Shelf-life stability of fresh-cuts melon coated with whey protein stored at low temperatures. Journal of Nutrition Sciences & Food Technology.; 5 (2):53-62.)In Persian with English abstract.(

5- Belletti N., Sadokamdem S., Patrignani F., Lanciotti R., Covelli A., and Gardini F. 2007. Antimicrobial activity of aroma compounds against Saccharomyces cerevisiae and improvement of microbiological stability of soft drinks as assessed by logistic regression. Applied and Environmental Microbiology,73:5580–5586.

6- Buta J.G., Moline H.E., Spaulding D.W., and Wang C.Y. 1999. Extending shelf-life of fresh-cut apples using natural products and their derivatives. Journal of Agricultural and Food Chemistry, 47:1–6.

7- Committee on the Review of the Use of Scientific Criteria and Performance Standards for Safe Food. 2003. Scientific Criteria to Ensure Safe Food. The National academies press, Washington, DC. Pp: 317-358.

8- Corbo M.R., Lanciotti R., Gardini F., Sinigaglia M., and Guerzoni M.E. 2000. Effects of hexanal, trans-2-hexenal, and storage temperature on shelf life of fresh sliced apples. Journal of Agricultural and Food Chemistry, 48: 2401–2408.

9- Costa C.A., Conte G.G., Buonocore M., Lavorgna and Nobile M.A. 2012. Calcium- alginate coating loaded with silver-montmorillonite nanoparticles to prolong the shelf-life of fresh-cut carrots. Journal of Food Research International ,48:164-169.

10-Del-Valle V., Hernandez-Munoz P., Guarda A., and Galotto M.J. 2005. Development of a Cactus mucilage edible coating (Opuntiaficus-indica) and its application to extend Strawberry (Fragaria ananassa) shelf-life. Journal of Food Chemistry, 91:751-756.

11-DongLin Z., and Hamauzu Y. 2004. Phenolic compounds and their antioxidant properties in different tissues of carrots (Daucus carota L.). Journal of Food Agricultural. Environ, 2: 95–100.

12-Emiroglut Z.K., Yemiş G.P., Coşkun B.K., and Candoğan k. 2010. Antimicrobial activity of soy edible films incorporated with thyme and oregano essential oils on fresh ground beef patties. Meat Science, 86: 283–288.

14-Gonzalez L.S., Vargas M., Martinez C.G., Chiralt A., and Chafer M. 2011. Use of essential oils in bioactive edible coatings. Food Engineering Reviews, 3:1–16.

13-Gago M.B., Serra M., Del M.A. 2006. Color change of fresh-cut apples coated with whey protein concentrate-based edible coatings. Journal of Post harvest Biology and Technology, 39 : 84–92.

15-Gutierrez J., Bourke P., Lonchamp J., and Barry-Ryan C. 2009. Impact of plant essential oils on morphological, organoleptic and quality markers of minimally processed vegetables. Innovative Food Science & Emerging Technologies, 10:195–202.

16-Huas S.T., Du W.X., Avena-Bustillos R.J., and Mchugh T.H. 2011. Novel approach to inhibit the growth of Aspergiluus flavus and aflatoxin production by essential oil edible film.111th General Meeting American Society for Microbiology. New Orleans, LA, May 21-24, (Abstract no: 11-GM-A-2474-ASM).

17-Javanmard M., and Golestan L. 2008. Effect of olive oil and glycerol on physical properties of whey protein concentrate films. Journal of Food Processing Engineering, 31: 628–639.

18-Martinez-Romero D., Alburquerque N., Valverde J.M., Guillen F., Castillo S., Valero D. and Serrano M. 2006. Postharvest sweet cherry quality and safety maintenance by Aloe vera treatment: A new edible coating. Journal of Post harvest Biology and Technology, 39: 93 – 100.

19-Nessrien M.N., Abou-Taleb Y., and Abou-Taleb M. 2007. Antioxidant and antimicrobial effects of marjoram and thyme in coated refrigerated semi fried mullet fish fillets. Journal of Dairy & Food Sciences, 2 (1): 01-09.

20-Nguyen C., and Carlin F. 1994. The microbiology of minimally processed fresh fruits and vegetables. Critical Reviews in Food Science and Nutrition, 34:371–401.

21- Omidbaigi R. 1995. Approaches to production and processing of medicinal plants, Fekr-e-Ruz Publication, 283pp.

22-Ozden C., and Bayindirli L. 2002.Effects of combinational use of controlled atmosphere, cold storage and edible coating applications on shelf life and quality attributes of apples. Journal of European Food Research Technology, 214: 320-26.

23-Paster E., Menasherov M., Ravid U., and Juven B. 1995. Antifungal activity of oregano and thyme essential oils applied as fumigants against fungi attacking stored grain. Journal of Food Protection, 58(1):81–85.

24-Pranoto Y., Salokhe V., and Rakshit K.S. 2005. Physical and antibacterial properties of alginate-based edible film incorporated with garlic oil. Journal of Food Research International, 38:267–272.

25-Pushkala R., Parvathy K.R., and Srividya N. 2012. Chitosan powder coating, a novel simple technique for enhancement of shelf life quality of carrot shreds stored in macro perforated LDPE packs. Innovative Food Science and Emerging Technologies, 16:11-20.

26-Rocha J., Ferreira L., Angelo M.M., Silva-

Gonc N., Almeida L, and Morais A. 2003. Quality of grated carrot (var. Nantes) packed under vacuum. Journal of Food Hydrocolloids.87(3), 447-451.

27-Rojas-Grau M.A. Tapia M.S., Rodriguez F.J., Carmona A.J., and Martin-Belloso O. 2007. Alginate and gellan-based edible coatings as carriers of antibrowning agents applied on fresh-cut Fuji apples. Journal of Food Hydrocolloids, 21: 118–127.

28-Rifat U., Akhtar M. S., and Khan M.S. 2006. In vitro antibacterial screening of Anethum graveolens L. fruit, Cichorium intybus L. leaf, Plantago ovate L. seed husk and Polygonum viviparum L. root extracts against Helicobacter pylori. International Journal of Pharmacology, 2: 674-677.

29-Serano U., Martinez-Romero D., Clastillo S. Guillen L., and Valevo D. 2005. The use of natural antifungal compounds improves the beneficial effect of MAP in sweet cherry storage. Innovative Food Science and Emerging Technologies, 6:ll5-123.

30-Sharifi A., Naghmachi M., Jahedi S. and Khosravani S.A.M. 2011. A Study on Antimicrobial Effects of Plantago psyllium. Armaghane Danesh magazine, 16(2): 191-199.( In Persian with English abstract)

31-Simesa A.J.A., Tudelab A., Allendeb R., and Puschmanna M. 2009. Edible coatings containing chitosan and moderate modified atmospheres maintain quality and enhance phytochemicals of carrot sticks. Journal of Postharvest Biology and Technology, 51: 364–370.

32-Tzonzakis N.G. 2007. Maintaining postharvest quality of fresh produce 'irh volatile compound. Inovatilc Food Science and Emerging Technoligies, 8: 111-116.

33-Wang C.Y. 2003. Maintaining postharvest quality of raspberries with natural volatile compounds. Journal of Food Science and Technology, 38: 869-875.