Effect of Harvesting Time and Drying Methods on the Quantity and Quality of the Essential Oil of Peppermint Medicinal Plant (Mentha piperita)

Document Type : Research Article

Authors

• Homeyra Hatami ¹
• Ghorbanali Rasam ²
• Alireza Dadkhah ¹

¹ Department of Production and Plant Genetic, Shirvan Faculty of Agriculture, University of Bojnord, Bojnord, Iran

² Associate Professor, Department of Plant Production and Genetics Engineering, Shirvan Faculty of Agriculture, University of Bojnord, Bojnord, Iran

https://doi.org/10.22067/jhs.2023.80799.1232

Abstract

Introduction   
Mint has been used both as a medicinal and aromatic plant since ancient times. Peppermint volatile oil is one of the most important essential oils and has strong antimicrobial activity. The stage at which the maximum essential oil is obtained from the plant is not necessarily the stage at which the plant has the most biomass, therefore, the appropriate time for harvesting the plant should be determined according to the maximum amount of the effective substance and the yield of dry matter. In most of the methods of producing medicinal plants, quick access to the equipment for extracting effective substances is not possible, especially at high levels, and this requires drying a large part of the plants and extracting the effective substance in subsequent times. The quality of dried medicinal plants is defined by the content of their biologically active compounds. This study was aimed to determine the best time to harvest peppermint and the effect of different drying methods on the shoots biochemical compounds.
 
Materials and Methods
In order to increase the yield of peppermint medicinal plant essential oil, two separate experiments were designed and conducted in Shirvan Higher Education Complex (N 26 37', E 45 57', altitude 1067 m) in 2015. The aim of first experiment was finding the best harvest time at three levels (Before flowering, at flowering 50 and 100%) and the second experiment was finding the best method for shoot drying with nine levels (Microwave radiation at 90, 180, 360, 600 and 900 watts; Oven at 40 and 60°C; Shade; and Sun), were based on a completely randomized block design (CRBD) and a completely randomized design (CRD), respectively. In the spring of 2015, tillage operations were carried out and after preparing the land, 9 plots (2 × 3 meters) were created in it. The distance between the plots was considered 1.5 m. Rizhomes of peppermint plant was obtained from Mashhad Agricultural and Natural Resources Research Center and transplanted at 20 × 30 cm intervals on May 26. Some morpholocial and biochemical traits were measured. Essential oil extraction was done by distillation method with water and essential oil components were determined by GC/Mass method.
 
Results and Discussion
The effect of harvesting time was significant (p≤0.01) on the plant height, number of leaves per plant, wet and dry yield of peppermint plant. The height of the plant after 50% flowering stage did not show any significant difference, but the other investigated traits include the number of leaves per plant, the wet and dry yield of the plant, the yield of essential oil in terms of wet and dry weight, and the inhibition of free radicals in the branches in shoots harvested at the time of full flowering had the highest amount, which showed a statistically significant difference. The yield of essential oil in terms of dry matter in the full flower stage increased 1.8 times compared to the 50% flowering stage and 4.6 times compared to the pre-flowering stage. The percentage of essential oil components was also affected by the harvest time, and the highest amount was observed in the full flowering stage (98.92 percent), include the highest amount in menthol (42.39 percent) and menthone (19.13 percent). The use of micro rays caused the shortest drying time, so that with the increase of power of micro rays, the drying time decreased and the shoots were dried in 0.16 hours at the power of 900 watts. The oven application at 60 and 40 °C were statistically ranked second and third in terms of drying speed with 10 and 14.6 hours. Sun and shade drying needed 46 and 109.6 hours to reach constant moisture, respectively. The highest amount of essential oil was obtained in the shade drying method (2.13%) and the lowest amount was observed in the microwave application at 900 and 600 watt. (0.01%). After shade drying, the highest amount of essential oil was observed in the oven method at 40 °C (2%) and in the sun drying (1.44%). According to the results of this study, it is recommended to harvest the branches at the time of full flowering and dry them using oven at 40 °C to obtain more essential oil yield of peppermint shoots.
 
Conclusion
In general, the harvesting time has a significant effect on the morphological characteristics and essential oil of the peppermint shoots. Harvesting peppermint in the full flowering stage resulted in the highest amount of essential oil and essential oil yield. The maximum height and number of leaves in the plant were obtained by harvesting at the time of full flowering, but the maximum wet and dry yield of shoots was observed at the harvest of 50% of flowering. The amount of menthol and menthone as the most important compounds of mint essential oil in the full flowering stage was higher than the other two harvesting times. Also, based on the results of this experiment, different methods of drying peppermint plant have various effects on the essential oil amount of peppermint shoots. The shortest time until drying was related to the use of microwave, oven, sun and shade, respectively, and the highest yield of essential oil was obtained in shade, oven at 40 °C, microwave at 90 watt and sun, respectively.

Keywords

• Full bloom
• Microwave
• Menthol
• Menthone
• Oven

Main Subjects

• Medicinal Plants

©2023 The author(s). This is an open access article distributed under Creative Commons Attribution 4.0 International License (CC BY 4.0), which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source.

References

1. Ahmadi, E. (2007). The effect of different drying and storage methods on the content and composition of peppermint essential oil (Mentha piperita). Rezaieh Faculty of Agriculture and Animal Husbandry, Urmia University, Urmia, Iran.
2. Akbarinia, A., Sharifi Ashoorabadi, E., & Mirza M. (2010). Study on drug yield and essential oil content and composition of Thymus daenensis under cultivated condition. Iranian Journal of Medicinal and Aromatic Plants Research, 26(2), 205-212. https://doi.org/10.22092/ijmapr.2010.6863
3. Arslan, D., Özcan, M.M., & Mengeş, H.O. (2010). Evaluation of drying methods with respect to drying parameters, some nutritional and colour characteristics of peppermint (Mentha x piperita). Energy Conversion and Management, 51(12), 2769–2775. https://doi.org/10.1016/j.enconman.2010.06.013
4. Azizi, M., Rahmati M., Ebadi, M.T., & Hasanzadeh khayyat, M. (2009). The effects of different drying methods on weight loss rate, essential oil and chamazolene contents of chamomile (Matricaria recutita) flowers. Iranian Journal of Medicinal and Aromatic Plants, 25(2), 182-192. https://doi.org/10.22092/ijmapr.2009.7239
5. Bertome, J., Isabel Arrillage, M., & Segura, J. (2007). Essential oil variation whit in and among natural population of Lavandula latifolia and its relation to their ecological areas. Biochemical Systematics and Ecology, 35, 479-488.
6. Blanco, M.C.S.G., Ming, L.C., Marques, M.O.M., & Bovi, O.A. (2002). Drying temperature effects in peppermint essential oil content and composition. Acta Horticulturae, 569, 95-98. https://doi.org/10.17660/ActaHortic.2002.569.15
7. Blose, N. (2001). Herb Drying Handbook: Includes Complete Microwave Drying Instructions. New York: Sterling Publishing Co. Inc.
8. Chalchat, J.C., Garry, R.P., & Michet, A. (1997). Variation of the chemical composition of essential oil of Mentha piperita during the growing time. Journal of Essential Oil Research, 9(4), 463-465. https://doi.org/10.1080/10412905.1997.9700750
9. Delaquis, D.J., Stanich, K., Girard, M., & Mazza, G. (2002). Antimicrobial activity of individual and mixed fractions of dill, cilantro, coriander and eucalyptus essential oils. International Journal of Food Microbiology, 74(1-2), 101-109. https://doi.org/10.1016/s0168-1605(01)00734-6
10. Diaz-Maroto, M.C., Perez-Coello, M.S., & Cabezudo, M.D. (2002). Effect of drying method on the volatiles in bay leaf (Laurus nobilis). Journal of Agricultural and Food Chemistry, 50(16), 4520–4. https://doi.org/10.1021/jf011573d
11. Ebadi, M.T., Azizi, M., Sefidkon, F., & Ahmadi, N. (2015). Influence of different drying methods on drying period, essential oil content and composition of Lippia citriodora Journal of Applied Research on Medicinal and Aromatic Plants, 2(4), 182-187. https://doi.org/10.1016/j.jarmap.2015.06.001
12. Ebrahimzadeh, M.A., Nabavi S.F., Nabavi, S.M., & Eslami, B. (2010). Antioxidant and antihemolytic activities of Mentha piperita. Pharmacologyonline, 1, 744-752.
13. Edris, A.E., Shalaby, A.S., Fadel, M.A., & Wahab, A. (2003). Evaluation of a chemo type of spearmint (Mentha spicata) grown in Siwa Oasis, Egypt. European Food Research and Technology, 218, 74–78. https://doi.org/10.1007/s00217-003-0802-4
14. Ekechukwu, O.V., & Norton, B. (1999). Review of solar-energy drying systems II: an overview of solar drying technology. Energy Convers Manage, 40, 615–655. https://doi.org/10.1016/S0196-8904(98)00093-4
15. Fathi, E., Sefidkon, F., Bakhshi Khaniki1, Gh. Abravesh, Z., & Assareh, M.H. (2009). The effects of drying and distillation methods on essential oil content and composition of Eucalyptus largiflorens. Iranian Journal of Medicinal and Aromatic Plants, 25(1), 64-74.
16. Işcan, G., Kirimer, N., Kürkcüoğlu, M., Başer, K.H., & Demirci, F. (2002). Antimicrobial screening of Mentha piperita essential oils. Journal of Agricultural and Food Chemistry, 50(14), 3943-6. https://doi.org/10.1021/jf011476k
17. Jaimand, K., Rezaee, M.B., & Askari, F. (2003). Comparative of two steam distillation apparatus (New design) and identification of chemical constituents on Mentha x piperita Iranian Journal of Medicinal and Aromatic Plants Research, 18(1), 11-22.
18. Jaimand, K., Rezaee, M.B., & Nabi, G.R. (2000). Essential oils composition of two cultivars of Mentha piperita Iranian Journal of Medicinal and Aromatic Plants Research, 6(1), 13-27.
19. Khorshidi, J., Omidbaigi, R., Sefidkon, F., Rostaei, A., & Fakhr Tabatabaei, M. (2009). The effect of climate and harvesting time on the quality of essential oil of Thymus daenensis Celak. Scientific Conference on the Development of Iranian Medicinal Plants Industry, March, Tehran. https://doi.org/10.22059/ijhs.2017.227727.1187
20. Kizil, S., Haşimi, N., Tolan, V., Kilinç, E., & Yüksel, U. (2010). Mineral content, essential oil components and biological activity of two Mentha species ( piperita L., M. spicata L.). Turkish Journal of Field Crops, 15(2), 148–153.
21. Lemos, D.R.H., Rocha, R.P., Melo, E.C., Visser, E., & Pinheiro, A.L. (2008). Influence of drying air temperature on the essential oil content from Melaleuca alternifolia Cheel. In: CIGR-International Conference of Agricultural Engineering, XXXVII Congresso Brasileiro de Engenharia Agricola, Brazil, 31 August-4 September. https://doi.org/10.15871/1517-8595%2Frbpa.v13n3p257-261
22. MirAhmadi, F., Omidbaigi, R., Sefidkon, F., Rostaei, A., & Fakhr Tabatabaei, M. (2009). Comparison of the quality of essential oil of Thymus fedtschenkoi in different stages of growth. Scientific Conference on the Development of Iranian Medicinal Plants Industry, March, Tehran.
23. Mumivand, H., Rezaei Nejad, A.H., Taghipour, Sh., Sepahvand, K., Moradi, B. (2020).Effect of different drying methods on drying time and some phytochemical characteristic of Pelargonium (Pelargonium graveolens). Journal of Horticultural Science, 33(4), 655-668.
24. Nikkhah, F., Sefidkon, F., & Sharifi Ashoorabadi, E. (2009). The effect of distillation methods and plant growth stages on the essential oil content and composition of Thymus vulgaris Iranian Journal of Medicinal and Aromatic Plants, 25(3), 309-320. https://doi.org/10.22092/ijmapr.2009.7146
25. Noruzi, F., Hojjati, M., Jooyandeh, H., & Barzegar, H. (2017). Study of the possibility of application oftarragonessential oil in mayonnaise as a natural additive. Journal of Food Research, 28(3), 85-99.
26. Omidbaigi, R. (2005). Production and Processing of Medicinal Plants (Volume 1). Tehran: Behnashr Publication, Iran.
27. Padmini, E., Valarmathi, A., & Usha Rani, M. (2010). Comparative analysis of chemical composition and antibacterial activities of Mentha spicata and Camellia sinensis. Asian Journal of Experimental Biological Sciences, 1(4), 772–781.
28. Rahmati, M., Azizi, M., Ebadi, M.T., & Hasanzadeh Khayat, M. (2010). Study on the effects of different drying methods on weight loss rate, essential oil and chamazolene contents of chamomile (Matricaria recutita Germania (Diploid)) flowers. Journal of Horticultural Science, 24(1), 29-37.
29. Risch, S.J. (1997). Spices: sources, processing, and chemistry. American Chemical Society.
30. Rocha, S.F.R., Ming, L.C., & Marques, M.O.M. (2000). Influence of five drying temperatures on themedicines (phytotherapeutic agents). Brazilian Journal of Medical and Biological Research, 33, 179-189. https://doi.org/10.5897/JMPRx11.001
31. Sadegi, T. (2007). Evaluation of the antioxidant effect of Iranian oregano essential oil. Dissertation of general veterinary course, final report of research project. Faculty of Veterinary Medicine. University of Tehran.
32. SAS Institute Inc. (1989). SAS/STAT User’s Guide, Version 9.4. SAS Institute, Inc., Cary.
33. Sefidkon, F., Abbasi, K., & Bakhshi Khaniki, G.B. (2006). Influence of drying and extraction method on yield and chemical composition of the essential oil of Satureja hortensis. Food Chemistry, 99(1), 19-23. https://doi.org/10.1016/j.foodchem.2005.07.026
34. Soysal Y., Oztekin S., & Eren, O. (2006). Microwave drying of parsley: modelling, kinetics, and energy aspects. Biosystems Engineer, 93(4), 403- 413. https://doi.org/10.1016/j.biosystemseng.2006.01.017
35. Sulieman, A.M.E., Abdelrahman, S.E., & Abdel Rahim, A.M. (2011). Phytochemical analysis of local spearmint (Mentha spicata) leaves and detection of the antimicrobial activity of its oil. Journal of Microbiology Research, 1(1), 1−4. https://doi.org/10.5923/j.microbiology.20110101.01
36. Sweetie, R., Kanatt, R.C., & Arun, S. (2007). Antioxidant potential of mint (Mentha spicata) in radiation –processed lamb meat. Food Chemistry, 100, 451-458. https://doi.org/10.1016/j.foodchem.2005.09.066
37. Tabatabaei Yazdi, F., Alizadeh Behbahani, B., Vasiee, A.R., Mortazavi, S.A.,& Shahidi, F. (2018). Evaluation antioxidant activity, phytochemical constituents and antimicrobial of Mentha piperita essential oil on some infectious and poisonous microorganisms. Journal of Food Science and Technology, 76(15), 67-76. http://dx.doi.org/10.30699/ijmm.13.3.210
38. Vega-Gálvez, A., Scala, K.D., KLemus-Mondaca, R., Miranda, M., López, J., & Perez-Won, M. (2009). Effect of air-drying temperature on physico-chemical properties, antioxidant capacity, colour and total phenolic content of red pepper (Capsicum annuum var. Hungarian). Food Chemistry, 117(4), 647- 53. https://doi.org/10.1016/j.foodchem.2009.04.066
39. Yadegari, M., Amirfakhriyan, Z., & Mohammadkhani, A. (2013). The effects of different drying methods on essential oil content and composition and marketing of Lippia citriodora Journal of Applied Science and Agriculture, 8(5), 624−628.
40. Yadegarinia, D., Gachkar, L., Rezaei, M.B., Taghizadeh, M., Astaneh, S.A., & Rasooli, I. (2006). Biochemical activities of Iranian Mentha piperita and Myrtus communis L. essential oils. Phytochemistry, 67(12), 1249-1255. https://doi.org/10.1016/j.phytochem.2006.04.025
41. Yazdani, D., Shahnazi, S., Jamshidi, A., Rezazadeh, S., & Mojab, F. (2006). Study on variation of essential oil quality and quantity in dry and fresh herb of Thyme and Tarragon. Journal of Medicinal Plants, 5(17), 7-15.